Coolant System Cleaning and Bleeding

Engine Specific.
Forum rules
To use Search function add Asterisks around the words like *fork oil*

No Racism.Slanging Matches(unless witty and funny :)
No spamming.Anonymous posting disabled.

Coolant System Cleaning and Bleeding

Postby Gman » Wed Jun 06, 2012 1:00 pm

You should change the coolant if you don't know how long it's been in and it's ability to cool the engine is as important as the oil.

Changing coolant

Mix up around 2.5 liters(0.25 US Gal) 50/50 coolant with Distilled water(Rain Water/Melted Freezer ice).I keep old Gallon plastic Oil for this cleaned out.Place a bowl under the radiator.

1: Remove the seat and tank.

2: Remove the Front Radiator guard.

3: Remove Radiator cap.

4: Remove 14mm nylon radiator drain plug with it's rubber washer.

5:Crank the engine with the kill switch activated a few times.This will help move more coolant out of the system.

6:Fill radiator(Check level with a Flashlight) to the bottom of the neck or even slightly below.



Replace the 14mm Radiator plug but only tighten gently as they are very low torque and can easily be broken.It should also have a rubber washer on it.If it doesn't have the washer you can make one out of some old Cycle inner tube and a pair of small scissors.

Bleeding system

Once you have filled the Radiator to about half an inch above the fins the cooling system needs to be bled to make sure there are no Airlocks.You do this by running the engine with the Radiator cap off and wait until the engine Temp gauge gets to the small,"Nominal" mark on the gauge and looking with the flashlight.When the you see the coolant flowing over the fins for a few times the air will have some out of the cooling system.This will also tell you that the Thermostat is working and the Water pump is doing it's job so it's a good system check

Don't forget to put the Radiator cap back on and the 14mm Drain plug in!
User avatar
Gman
Site Admin
 
Posts: 1141
Joined: Thu Jul 24, 2008 8:11 pm
Location: Hull.Yorkshire.UK.2x1980 CX500ZABs:Citroen ZX TD(250,000 miles)

Return to Engine Section

Who is online

Users browsing this forum: No registered users and 1 guest

Help keep this forum ad-free - please Donate


This free, ad-free forum is hosted by ForumLaunch
cron